Product ID:SCOTCH-GRIP 847 RUBBER AND GASKET ADHESIVE,51893
MSDS Date:11/25/1997
FSC:5330
NIIN:01-417-2682
Kit Part:Y
MSDS Number: CFZCW

MINNESOTA MINING AND MFG CO AUTOMOTIVE TRADES DIV

3M CTR
ST PAUL, MN 55144-1000
US

Emergency Phone: 612-737-6501/800-364-3577

Info Phone: 612-733-1110

Cage: 52157

SAN DIEGO SEAL CO

SAN DIEGO, CA 92111 US

Telephone: 619-278-3270

Cage: 3R262

ACETONE (SARA 313) (CERCLA)

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 60 - 70%

OSHA PEL 1000 PPM

ACGIH TLV: 750PPM/1000STEL;9596

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACRYLONITRILE BUTADIENE POLYMER

CAS: 9003-18-3

Fraction By Weight: 10 - 20%

PHENOL-FORMALDEHYDE RESIN/POLYMER

CAS: 9003-35-4

Fraction By Weight: 7 - 13%

GLYCEROL ESTERS OF ROSIN ACIDS/RESIN ACIDS & ROSIN ACIDS,

CAS: 8050-31-5

Fraction By Weight: 7 - 13%

SALICYLIC ACID

CAS: 69-72-7

RTECS: VO0525000

Fraction By Weight: 1 - 5%

ZINC OXIDE (SARA 313) (CERCLA)

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: <25%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9596

ANTIOXIDANT/BENZENAMINE, N-PHENYL-,

CAS: 68411-46-1

Fraction By Weight: <1%

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, CNS,
RESPIRATORY AND GI TRACTS. ACUTE- EYE:MODERATE IRRITATION.
SKIN:MILD IRRITATION AFTER REPEATED/PROLONGED EXPOSURES.
INHALE:CENTRAL NERVOUS SYSTEM DEPRESSION. ORAL:MAY CAU SE
GASTROINTESTINAL TRACT IRRITATION, VOMITING. ASPIRATION HAZARD.
CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, HEADACHE,
DIZZINESS, DRY SKIN, DEFATTING, WEAKNESS, FATIGUE, BLOOD IN FECES
AND VOMITUS, BLURRED VISION, ITCHING, SWELLING
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED CNS OR RESPIRATORY FUNCTION MAY
BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.

First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES:IMMEDIATELY
FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. SKIN:WASH WITH
SOAP & WATER. INHALED:MOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF
NECESSARY. ORAL:CALL A PHYSICIAN IMMEDIATELY. DO NOT INDUCE
VOMITING EXCEPT ON ADVICE OF A PHYSICIAN. DO NOT GIVE ANYTHING BY
MOUTH TO AN UNCONS PERSON.

Flash Point Method:TCC
Flash Point:0F,-18C
Lower Limits:2.6
Upper Limits:12.8
Extinguishing Media:USE CARBON DIOXIDE, SAND, FOAM/DRY CHEMICAL. WATER
SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING, INCLUDING
HELMET AND NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACEPIECE OPERATED IN POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. VENTILATE AREA.
PICK UP SPILL WITH NON-FLAMMABLE ABSORBENT SUCH AS SAND,
VERMICULITE. PLACE IN CONTAINER FOR DISPOSAL OR REUSE.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED PLACE
AWAY FROM IGNITION SOURCES & STRONG OXIDIZING AGENTS.
Other Precautions:FLAMMABLE. "EMPTY" CONTAINERS RETAIN RESIDUE AND CAN
BE DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER OR DRILL.
KEEP OUT OF REACH OF CHILDREN. AVOID BREATHING VAPORS. DO NOT GET
IN EYE, ON SK IN OR ON CLOTHING. DO NOT INGEST.

Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. WEAR A NIOSH-APPROVED ORGANIC VAPOR RESPIRATOR IN
ENCLOSED, UNVENTILATED AREAS.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:NITRILE RUBBER IF REPEATED CONTACT
Eye Protection:SAFETY GLASSES WITH SIDE SHIELD/GOGGLES
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING OR
DRINKING.
Supplemental Safety and Health
KEY1:F3 PER TECHNICAL SUPPORT. FOR OTHER PART, SEE UNDER CAGE 01139,
SAME NSN.

HCC:F3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:132F,56C
Vapor Pres:180 @ 68F
Vapor Density:2.0
Spec Gravity:0.91
Evaporation Rate & Reference:>1 (N-BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:DARK BROWN LIQUID - SHARP SOLVENT ODOR
Percent Volatiles by Volume:64

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES, HOT SURFACES
AND OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
NITROGEN OXIDES, HYDROGEN CYANIDE, ALDEHYDES, KETONES,
HYDROCARBONS, ZINC OXIDE

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DISPOSE OF IN AN APPROVED INCINERATOR OR
CONTRACT WITH A LICENSED WASTE DISPOSAL SERVICE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.